-
●非對稱異性隧道聯絡通道冷凍法(07月24日)
-
●水泥夯土材料抗壓強度試驗及耐(08月25日)
-
●粉煤灰基超高性能混凝土配合比(07月25日)
-
●大體積混凝土配合比優化設計在(08月25日)
-
●變質巖類順層邊坡破裂跡象及邊(07月25日)
-
●地鐵車輛段檢修庫裝配式混凝土(07月24日)
-
●變坡面淺埋偏壓小凈距隧道圍巖(07月24日)
-
●大型十字交叉地鐵車站結構地震(07月25日)
-
●自密實抑溫防水復合材料在地下(08月25日)
-
●邯鄲富水地層深基坑支護優化和(07月25日)
-
●地鐵盾構隧道水泥基同步注漿減(03月05日)
-
●纖維煤矸石基泡沫混凝土性能影(03月17日)
-
●粉煤灰渣細骨料混凝土強度及耐(03月17日)
-
●降雨入滲對高速公路高路塹邊坡(03月18日)
-
●氧化石墨烯對水泥基材料微納米(03月17日)
-
●新澤西混凝土預制護欄制備及性(03月18日)
-
●基于智能監測深基坑對鄰近管廊(03月18日)
-
●深基坑開挖變形規律及周邊環境(03月18日)
-
●側向剛度與損傷作用下巖體強度(03月18日)
-
●多源固廢交通工程附屬構件配合(03月18日)
PDF全文閱讀
柏延平1 , 夏 懿1 , 馬 雷1 , 雒億平2
( 1 . 國網甘肅省電力公司臨夏供電公司 ,臨夏 731100 ;
2. 西安理工大學 西北旱區生態水利國家重點實驗室 ,西安 710048)
摘 要 :研究旨在開發粉煤灰基地聚物固化劑替代水泥用于黃土加固 , 以粉煤灰為主要前驅體 ,偏高嶺土為鋁質校正料 ,硅酸鈉與氫氧化鈉復合配制堿激發劑 ,通過正交試驗考察堿激發劑模數 、固體摻量及粉煤灰摻量對抗壓強度的影響。結果表明:最優配比為堿激發劑模數 1 . 1 、固體摻量 7% 、粉煤灰摻量 30% , 對應的固化土 7 、14 、28 d 抗壓強度分別達到 5. 11 、6. 16 、10. 71 MPa。進一步按粉煤灰與偏高嶺土質量比 1 : 1 調整硅鋁比, 7 d 強度較基準組提升 77. 9% , 地聚物固化土在硫酸鹽溶液中未出現膨脹開裂 ,表現出良好的耐蝕性。該配比體系兼顧力學性能與環境適應性 ,可為黃土地區低碳地基處理提供技術支持。
關鍵詞:粉煤灰 ;地聚物 ;鋁質校正料 ;耐久性
中圖分類號:TU433
文獻標志碼:A
文章編號: 1005- 8249 (2025) 05- 0008- 06
DOI:10. 19860/j.cnki.issn1005 - 8249.2025 .05 .002
BAI Yanping1 , XIA Yi 1 , MA Lei 1 , LUO Yiping2
( 1 . State Grid Gansu Linxia Power Supply Company , Linxia 731100 , China; 2. State Key Laboratory of Eco - hydraulics in Northwest Arid Region , Xi ’an University of Technology , Xi ’an 710048 , China)
Abstract : The purpose of this study is to develop fly ash based polymer curing agent to replace cement for loess reinforcement. The alkali activator was prepared by using fly ash as the main precursor , metakaolin as the aluminum correction material , sodium silicate and sodium hydroxide . The effects of alkali activator modulus , solid content and fly ash content on compressive strength were investigated by orthogonal test. The results show that the optimal ratio of alkali activator modulus is 1 . 1 , the solid content is 7% , and the fly ash content is 30% . The compressive strength of the corresponding solidified soil at 7 days , 14 days , and 28 days reaches 5. 11 MPa , 6. 16 MPa , and 10. 71 MPa , respectively. The silica - alumina ratio was further adjusted according to the mass ratio of fly ash to metakaolin of 1 : 1 , and the 7 - day strength was
77. 9% higher than that of the reference group . The geopolymer solidified soil did not expand and crack in the sulfate solution , showing good corrosion resistance . The ratio system takes into account both mechanical properties and environmental adaptability , and can provide technical support for low - carbon foundation treatment in loess areas .
Key words : fly ash; geopolymer; aluminum correction material; durability
基金項目: 西北旱區生態水利國家重點實驗室開放課題 (XB15468) 。
作者簡介:柏延平 (1994—) , 男 ,本科 ,高級工程師 ,研究方向:基礎沉陷 、地基變形預測分析。
通信作者:雒億平 (1984—) , 男 ,博士 ,教授 ,研究方向:水工混凝土新材料地基變形預測分析。
收稿日期:2025 - 03 - 10
冀公網安備13011002000529 技術支持:數字河北 