-
●非對稱異性隧道聯絡通道冷凍法(07月24日)
-
●水泥夯土材料抗壓強度試驗及耐(08月25日)
-
●粉煤灰基超高性能混凝土配合比(07月25日)
-
●大體積混凝土配合比優化設計在(08月25日)
-
●變質巖類順層邊坡破裂跡象及邊(07月25日)
-
●地鐵車輛段檢修庫裝配式混凝土(07月24日)
-
●變坡面淺埋偏壓小凈距隧道圍巖(07月24日)
-
●大型十字交叉地鐵車站結構地震(07月25日)
-
●自密實抑溫防水復合材料在地下(08月25日)
-
●邯鄲富水地層深基坑支護優化和(07月25日)
-
●地鐵盾構隧道水泥基同步注漿減(03月05日)
-
●纖維煤矸石基泡沫混凝土性能影(03月17日)
-
●粉煤灰渣細骨料混凝土強度及耐(03月17日)
-
●降雨入滲對高速公路高路塹邊坡(03月18日)
-
●氧化石墨烯對水泥基材料微納米(03月17日)
-
●新澤西混凝土預制護欄制備及性(03月18日)
-
●基于智能監測深基坑對鄰近管廊(03月18日)
-
●深基坑開挖變形規律及周邊環境(03月18日)
-
●側向剛度與損傷作用下巖體強度(03月18日)
-
●多源固廢交通工程附屬構件配合(03月18日)
PDF全文閱讀
郝利斌1 , 董澤彬2 , 郭 峰1
( 1 . 華冠天誠檢測認證有限公司 ,太原 030000 ; 2. 西南交通大學 ,成都 611730)
摘 要 :為了提高鐵尾礦的利用效率 ,并降低混凝土材料的生產成本 , 以鐵尾礦砂取代部分天然砂作為細骨料 ,并摻入鋼纖維 ,制備出了鐵尾礦-鋼纖維復合粉煤灰基混凝土。通過抗壓強度和劈裂抗拉強度試驗評價了鐵尾礦和鋼纖維摻量對混凝土力學性能的影響 ,通過碳化試驗和鹽霧侵蝕試驗評價了混凝土的耐老化性能。結果表明:鋼纖維的長度和摻量越大 ,鐵尾礦砂的摻量越大時 ,混凝土的抗壓強度和劈裂抗拉強度均先升高后降低 ,當鋼纖維的長度為 35 mm , 摻量為 1 . 5% , 鐵尾礦砂的摻量為 40% 時 ,混凝土的力學性能達到最佳 ,抗壓強度和劈裂抗拉強度分別為 30. 08 、6. 64 MPa。鐵尾礦-鋼纖維復合混凝土的耐老化性能較好 , 當碳化齡期和鹽霧侵蝕齡期達到 56 d 時 ,混凝土的碳化深度為 12. 8 cm , 碳化試驗后的抗壓強度為 36. 72 MPa , 鹽霧侵蝕試驗后的抗壓強度為 29. 51 MPa。
關鍵詞:鐵尾礦 ;鋼纖維 ;粉煤灰基混凝土 ;力學性能 ;耐老化性能
中圖分類號:TU528 文獻標志碼:A 文章編號: 1005- 8249 (2026) 01- 0037- 06
DOI:10. 19860/j.cnki.issn1005 - 8249.2026.01 .007
HAO Libin1 , DONG Zebin2 , GUO Feng1
( 1 . Huaguan Tiancheng Testing and Certification Co . , Ltd. , Taiyuan 030000 , China;
2. Southwest Jiaotong University , Chengdu 611730 , China)
Abstract : In order to improve the utilization efficiency of iron tailings and reduce the production cost of concrete materials , iron tailings sand was used to replace some natural sand as fine aggregate , and steel fibers were added to prepare iron tailings steel fiber composite fly ash based concrete. The influence of iron tailings and steel fiber content on the mechanical properties of concrete was evaluated through compressive strength and splitting tensile strength tests , and the aging resistance of concrete was evaluated through carbonation tests and salt spray erosion tests . The results showed that as the length and dosage of steel fibers increased and the dosage of iron tailings sand increased , the compressive strength and splitting tensile strength of concrete first increased and then decreased. When the length of steel fibers was 35mm , the dosage of steel fibers was 1 . 5% , and the dosage of iron tailings sand was 40% , the mechanical properties of concrete reached their optimum , with compressive strength and splitting tensile strength of30. 08 、6. 64 MPa , respectively. The aging resistance of iron tailings steel fiber composite concrete is good. When the carbonation age and salt spray erosion age reach 56 days , the carbonation depth of the concrete is 12. 8 cm , and the compressive strength after carbonation test is 36. 72 MPa , and the compressive strength after salt spray erosion test is 29. 51 MPa.
Key words : iron tailings; steel fiber; fly ash based concrete; mechanical properties; aging resistance
作者簡介:郝利斌 (1989—) , 男 ,本科 ,高級工程師 ,研究方向:試驗檢測。
通信作者:董澤彬 (2005—) , 男 ,本科在讀 ,研究方向:材料科學與工程。
收稿日期:2025 - 10 - 24
冀公網安備13011002000529 技術支持:數字河北 